Two more members of the Board of Directors, four Belgian engineers, and several big shareholders arrived from Petersburg after Kvashnin. It was rumoured among the mill personnel that the Board had allocated about two thousand rubles for the celebration dinner, but so far nothing had happened to bear out these rumours, and the contractors had to shoulder the whole burden of buying wines and food.
Luckily the day of the celebration was fine – one of those bright, limpid days of early autumn when the sky seems so intensely blue and deep and the cool air is like exquisite, strong wine. The square pits, dug out for the foundations of the new blower and bessemer, were surrounded by a dense crowd of workers forming a U. In the middle of this living wall, on the edge of the pit, stood plain, unpainted table covered with a white cloth, on which a cross and a gospel-book lay beside a sprinkler and a tin bowl for holy water. The priest, attired in a green chasuble embroidered with golden crosses, was standing a little way off, at the head of fifteen workmen who had volunteered to serve as choristers. The open side of the U was taken up by engineers, contractors, senior foremen, clerks – a motley, bustling crowd of two hundred-odd people. A photographer was busy on the embankment, with a black cloth thrown over his head and the camera.
Ten minutes later Kvashnin arrived at the site in a troika of magnificent greys. He was all alone in the carriage, for no one else could possibly have squeezed in beside him. He was followed by five or six more vehicles. Instinctively the workmen at once recognized him as “the boss” and took off their caps as one man. Kvashnin stalked past them and nodded to the priest.
The hush that fell was broken by the jarring little nasal tenor of the priest, who chanted meekly, “Bless’d be the Lord, for ever and ever.”
“Amen,” the improvised choir responded, harmoniously enough.
The workmen – there were some three thousand of them – crossed themselves broadly, doing it simultaneously as they had greeted Kvashnin, bowed their heads, raised them again, and tossed back their hair. Bobrov could not help looking at them closely. Standing in the two front rows were staid stone-masons, all of them wearing white aprons, and nearly all tow-haired and red bearded; behind them were smelters and forge workers in wide, dark blouses styled after those worn by the French and British workmen, their faces grimy with iron dust which could not be washed off; among them appeared the hook-nosed faces of foreign ouvriers; still farther away, behind the smelters and forge workers, you could catch glimpses of limekiln workers, recognizable from afar by their faces, which seemed to be thickly powdered with flour, and by their inflamed, bloodshot eyes.
Whenever the choir chanted in loud unison, “Save Thy servants from calamity, О Lady!” all the three thousand people assiduously crossed themselves with a soft, monotonous rustle, and bowed deeply. Bobrov fancied that there was something elemental and powerful, and at the same time childish and touching, in that common prayer of the huge grey crowd. Next day the workmen would set about their hard twelve-hour toil. Who knew which of them was already doomed to pay for that toil with his life – to fall from a high scaffold, to be scorched with molten metal, or to be buried under a pile of broken stone or bricks? And was it by any chance this immutable decision of fate that they were thinking of as they made deep bows and tossed back their fair locks, while the choir prayed Our Lady to save her servants from calamity? And in whom but the Virgin could they trust, these big children with stout, simple hearts, these humble heroes who came out daily from their dank, cold mud-huts to carry out their habitual feat of patience and daring?
Such, or almost such, were the thoughts of Bobrov, who had an inclination for vast, poetic pictures; and although he had long since grown out of the habit of praying, a thrill of nervous excitement ran down his spine whenever the priest’s jarring, distant voice was succeeded by the harmonious response of the choir. There was something powerful, submissive, and self-sacrificing in the naive prayer of those simple toilers, who had come together from God knew what far-away regions, snatched from their homes for hard and perilous work.
The service was over. With a careless air Kvashnin threw a gold coin into the pit, but was unable to bend down with the little spade he held, and so Shelkovnikov did it for him. Then the group started for the blast-furnaces whose black towers rose on stone foundations.
The newly-built Fifth Furnace was going “full blast,” to use the technical jargon. A seething white-hot stream of molten slag sent blue sulphur flames darting about as it gushed from a hole pierced in the furnace, about thirty inches above the ground. It flowed down a shoot into ladles placed against the vertical base of the fur-mace, and there hardened into a thick greenish mass like barley sugar. The workmen standing on top of the furnace kept on feeding it with ore and coal, which went up every other minute in trolleys.
The priest sprinkled the furnace on all sides with holy water and hurried off timidly, with the stumbling gait of an old man. The foreman in charge of the furnace, a sinewy, black-faced old man, crossed himself and spat into his palms. His four assistants did the same. Then they picked up a long steel crow-bar, swung it back and forth for a long time and, with one big gasp, rammed it into the lowest part of the furnace. The crow-bar clanked against the clay plug. The onlookers shut their eyes in nervous expectation, and some of them stepped back. The five men struck for the second, third, and fourth time, and suddenly a dazzling-white jet of molten metal burst forth from where the crow-bar had struck. Then the foreman widened the hole by rotating the crow-bar, and the cast iron flowed sluggishly down a sand furrow, taking the colour of fiery ochre. Clusters of big shining stars came flying out of the hole, crackling and melting in the air. Flowing at a seemingly lazy pace, the metal sent out such an unbearable heat that the unaccustomed visitors kept on moving farther and farther back, shielding their faces with their hands.
From the blast-furnaces the engineers made for the blower department. Kvashnin had seen to it that the visiting shareholders got a full view of the enormous mill bustling with activity. He had calculated with absolute accuracy that these gentlemen would be overwhelmed by the wealth of new impressions, and would later report wonders to the general meeting which had sent them. And knowing very well the psychology of business men, he confidently looked forward to a new issue of stock, which would greatly profit him personally and which the general meeting had so far refused.
And the shareholders were overwhelmed, so much so that their heads ached and their knees trembled. In the blower shop, pale with excitement, they heard the air, forced into pipes by four vertical fifteen-foot pistons, rush through them with a roar that rocked the stone walls of the building. Along these massive iron pipes, which were about ten feet in circumference, the air passed through the hot-blast stoves, where burning gases heated it to a thousand degrees, and from there went into the blast-furnace, melting ore and coal with its hot breath. The engineer in charge of the blower department was giving explanations. He bent to the ear of one shareholder after another, and shouted at the top of his voice, straining till his lungs hurt, but the terrific din of the machinery drowned his words and it seemed as if he were just moving his lips, silently and strenuously.
Then Shelkovnikov led the visitors to the puddling-furnace shed, a tall building of such immense length that its far end looked like a barely visible small hole. Along one wall of the shed ran a stone platform with twenty puddling furnaces shaped like railway wagons without wheels. In these furnaces molten iron was mixed with ore and processed into steel, which flowed down pipes and filled high iron moulds – rather like bottomless cases with handles on top – and there hardened to puddles weighing each about three-quarters of a ton. The other side of the shed was laid with rails along which steam cranes moved up and down like obedient, agile animals, with tensile trunks, snorting, hissing, clanking. One of the cranes would seize a mould by the handle and raise it, and a dazzling red bar of steel would slip out. But before the bar could reach the floor, a workman would with extraordinary alacrity sling a wrist-thick chain round it. Another crane would hook the chain, waft away the bar, and put it down next to others on the platform attached to a third crane. The third crane would haul the load to the far end of the shed where a fourth crane, equipped with pincers instead of a hook, would lift the bars from the truck and lower them into the gas furnaces built under the floor. Lastly, a fifth crane would pull them, white with heat, out of the furnaces, put them one by one under a sharp-toothed wheel revolving on a horizontal axle at a terrific speed, and the huge steel bar would be halved in five seconds like a slab of butter. Each half would then go under the twenty-five thousand pound press of a steam hammer, which shingled it as easily as if it were wax. Workmen would at once grab and load the pieces on trolleys and push them away at a run, the red-hot iron sending a wave of glowing heat against all who came that way.